International Journal of Environmental Chemistry

| Peer-Reviewed |

Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment

Received: Oct. 06, 2018    Accepted: Nov. 08, 2018    Published: Dec. 26, 2018
Views:       Downloads:

Share This Article

Abstract

The treatment of petroleum produced water before discharge has been made a legal requirement to protect water resources and avoid acute and chronic toxicities. Activated carbon (AC) has been widely used worldwide as an effective medium for the adsorption of biological and chemical contaminants in advance waste water, but its use is limited by its high cost. This study aimed to apply locally prepared activated carbons from coconut and palm kernel shells waste for the abatement of chemical oxygen demand (COD), turbidity, total alkalinity and conductivity in petroleum produced water. Chemical analyses of the petroleum produced water were done to establish the characteristics of the water before and after contacting with the activated carbons for 60 min. The results revealed the COD was reduced to 9.38% by PKSAC, 15.63% by CNTAC and 45.31% by ZC at the 45th min. The total alkalinity reduction was 27.27% for both PKSAC and CNTAC, and 36.36% for ZC. Also, turbidity of the waste water was reduced to 3.48% for CNTAC, 5.56% for PKSAC at the end of 60 min but an anomaly was observed for ZC, where the percentage turbidity of the water increased from 2.78% to 5.36% from the first 45 to the 60 min. The reduction of conductivities of the solution occurred in the first 15 min. The anomalous behaviours observed by all the carbons are an indication of the consumption of vacant active sites on the surface of the carbons for further uptake. This study has revealed some latent facts about the usefulness and effectiveness of granular activated carbons produced from agricultural waste materials which advances existing knowledge in the use of local agro-waste materials for AC preparation.

DOI 10.11648/j.ijec.20180202.14
Published in International Journal of Environmental Chemistry ( Volume 2, Issue 2, December 2018 )
Page(s) 49-55
Creative Commons

This is an Open Access article, distributed under the terms of the Creative Commons Attribution 4.0 International License (http://creativecommons.org/licenses/by/4.0/), which permits unrestricted use, distribution and reproduction in any medium or format, provided the original work is properly cited.

Copyright

Copyright © The Author(s), 2024. Published by Science Publishing Group

Keywords

Produced Water, Activated Carbon, Adsorption, Waste Water Treatment

References
[1] Fakhru’l-Razi, A., Alireza, P., Luqman, C. H., Dayang, R. A. B., Sayed, S. M. and Zurina, Z. A. (2009), “Review of Technologies for Oil and Gas Produced Water”, Journal of Hazardous Materials, Vol. 170, pp. 530-551.
[2] Al-Malack, H. and Muhammed, H. (2013), “Treatment of Petroleum Refinery Waste Water using Cross Flow and Immersed Membrane Process”, Desalination and Water Treatment”, Vol. 51, pp. 6985-6993.
[3] Ray, J. P. and F. Rainer Engelhardt (1992), Produced Water: Technological/Environmental Issues and Solutions, Vol. 46 of Environmental Science Research, Springer, New York, NY, USA,
[4] Sirivedhin, T., McCue, J. and. Dallbauman, L (2004), “Reclaiming Produced Water for Beneficial Use: Salt Removal by Electrodialysis,” Journal of Membrane Science, Vol. 243, No. 1-2, pp. 335–343.
[5] Perez-Casanova, J. C., Hamoutene, D., Samuelson, S., Burt, K., King, T. L., Lee, K., (2010). The Immune Response of Juvenile Atlantic Cod (Gadus Morhua L.) to Chronic Exposure to Produced Water. Mar Environ. Res.70,26-34. http://dx.doi.org/j.marenvres.2010.02.005.
[6] Igwe, C. O., Saadi, A. A. L. and Ngene, S. E. (2013), Optimal Options for Treatment of Produced Water in Offshore Platforms. Journal of Pollution Effect and Control. Vol. 1, No. 1: pp; 1-5.
[7] Ghana National Petroleum Corporation (2008), “Status Report Jjubilee Field”, GNPC, Accra. Available online at http://www.gnpcghana.com/_upload/general/status%20report-jubilee%20field_reviesed.pdf, updated on 17/09/2008, accessed on 06/09/2013.
[8] Neff, J. M., Lee, K., DeBlois, E. M, (2011). Produced Water: Overview Of Composition, Fates And Effects In: Lee, K., Neff, J. (Eds.), Produced Water, Springer New York, pp. 3-54.
[9] Nasiri, M. And Jafari, I. (2017) Produced Water From Oil-Gas Plants; A Short Review On Challenges and Opportunities; Periodica Polytechnica Chemical Eng. Vol. 61, No. 2, Pp. 73-81.
[10] Saleh, T. A., and Gupta, V. K. (2014) “Processing Methods, Characteristics and Adsorption Behaviour of Tire Derived Carbons. A Review”. Advance in Colloid and Interface Science, Vol. 211, pp. 93 – 101.
[11] Arthur, J. D., Langhus, B. G. and Patel, C. (2005), “Technical Summary of Oil and Gas Produced Water Treatment Technologies”, All Consulting, LLC, Tulsa.
[12] Ravanchi, M. T., Kaghazchi, T. And Kagari, A. (2009), “Application of Membrane Separation Process in Petrochemical Industry. A Review on Desalination”, Vol. 235, No. 1-3, Pp. 199-244.
[13] Tan, I. A. W., Ahmad A. L., and Hameed, B. H. (2008), “Preparation of Activated Carbon from Coconut Husk: Optimization Study on Removal of 2, 4, 6-Trichlorophenol Using Response Surface Methodology”, Journal of Hazardous Materials, Vol. 153, pp. 709–717
[14] Maiti, S., Purakayastha, S. and Ghosh, B. (2008), “Production of Low Cost Carbon Absorbents from Agricultural Wastes and their Impact on Dye Adsorption”, Chem. Eng. Comm., Vol. 195, pp. 386 – 403
[15] Jabit, N. B. (2007), “The Production and Characterisation of Activated Carbon using Local Agricultural Waste through Chemical Activation Process”, Unpublished MSc, Thesis, Universiti Sains Malaysia, Malaysia, 43pp.
[16] Ntuli, V. and Hapazari, I. (2013), “Sustainable Waste Management by Production of Activated Carbon from Agroforestry Residues”, South African Journal of Science, Vol. 109, No.1/2, pp. 1-6.
[17] Misihairabgwi, J., Ntuli, V., Kasiyamhuru, A., Zinyowera, S., Ncube, I. and Chipofya, V. (2007), “Application of Locally Produced Activated Carbons in Water Treatment”, UNESCO-IHE Institute of Water Education, pp.1-22.
[18] Buah, W. K. and Williams, P. T. (2013), “Granular Activated Carbons from Palm Nut Shells for Gold Di-cyanide Adsorption”, Intern. Journal of Minerals, Metallurgy and Materials, Vol. 20, No. 2, pp.1-8.
[19] Quartey, E. T. and Chylkova, J. (2013), “Challenges and Opportunities in Managing Agricultural waste in Ghana” Advances in Environment, Biotechnology and Biomedicine, pp. 235-239.
[20] Bentil, J. and Buah, W. K. (2017), “Effects of Physical Activated Procedure on the Production Yield, Surface Chemistry nd Surface Pores of Coconut Shells Based Activated Carbons”, Journal of Chemistry and Materials Research, Vol. 9. (3), pp. 29-35.
[21] Brunauer, S., Emmett, P. H. and Teller, J. (1938), “Adsorption of Gases in Multimolecular Layers”, Journal of the American Chemical Society, Vol. 60, pp. 309-319.
[22] Boonpoke, A., Chiarakorn, S., Laosiripojana, N., Towprayoon, S. and Chidthaisong, A. (2011), “Synthesis of activated carbon and MCM-41 from Bagasse and Rice Husk and their Carbon Dioxide Adsorption Capacity”, Journal of Sustainable Energy and Environment, Vol. 2, pp. 77-81.
[23] Anon. (1990) “Standard Test Method for Iodine Number in Activated Carbon”, American Standard for Testing of Materials, ASTM D 4607-862.
[24] Jog, D. C. (1997),”Scanning Electron Microscopy for Materials Characterisation”, Curr. Opin. Solid State Mater. Sci., Vol. 2, pp. 465–468.
[25] Bae, W., Kim, J. and Chung, J. (2014), “Production of Granular Activated Carbon from Food-processing Wastes (Walnut Shells and Jujube Seeds) and Its Adsorptive Properties”, Journal of Air and Waste Management Association, Vol. 64, pp. 879-886.
[26] Anon. (1989), America Public Health Association Standard (APHA) Methods for the Examination of Wastewater, 541pp.
[27] Clesceri, L. S., Greenberg, A. E. and Rhodes, T. (1989), “Standard Methods for the Examination of Water and Wastewater”, 17th Edition, American Public Health, 541pp.
[28] Gergova, K., Petrove, N. and Eser, S. (1994), “Adsorption Properties and Microstructure of Activated Carbons Produced from Agricultural By–products by Steam Pyrolysis”, Carbon, Vol. 32, No. 4, pp. 693-702.
[29] Baccar, R., Bouzid, J., Feki, M. and Montiel, A. (2009), “Preparation of Activated Carbon from Tunision Olive-waste Cake and its Application for Adsorption of Heavy Metal Ions”, Journal of Hazardous Materials, Vol. 162, pp. 1522-1529.
[30] Satayev, M. I., Alibekov, R. S., Satayeva, L. M., Baiysbay, O. P. and Mutaliyeva, B. Z. (2015), “Characteristics of Activated Carbons Prepared from Apricot Kernel Shells by Mechanical, Chemical and Thermal Activations”, Modern Applied Science, Vol. 9, No. 6, pp. 1913-1952.
[31] Wirnkor, V. A., Amonia, B. O. and Ngozi, V. E. (2014), “Batch and Column Adsorption of BOD and COD in Vegetable il Industry Effluents Using Activated Carbon from Flute Pumpkin (Telfaina, Occidentalis . Hook. F) Seed Shell”, Int. Letters of Chemistry, Physics and Astronomy, Vol. 39, pp. 64-77.
Cite This Article
  • APA Style

    John Bentil, William Kwame Buah. (2018). Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment. International Journal of Environmental Chemistry, 2(2), 49-55. https://doi.org/10.11648/j.ijec.20180202.14

    Copy | Download

    ACS Style

    John Bentil; William Kwame Buah. Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment. Int. J. Environ. Chem. 2018, 2(2), 49-55. doi: 10.11648/j.ijec.20180202.14

    Copy | Download

    AMA Style

    John Bentil, William Kwame Buah. Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment. Int J Environ Chem. 2018;2(2):49-55. doi: 10.11648/j.ijec.20180202.14

    Copy | Download

  • @article{10.11648/j.ijec.20180202.14,
      author = {John Bentil and William Kwame Buah},
      title = {Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment},
      journal = {International Journal of Environmental Chemistry},
      volume = {2},
      number = {2},
      pages = {49-55},
      doi = {10.11648/j.ijec.20180202.14},
      url = {https://doi.org/10.11648/j.ijec.20180202.14},
      eprint = {https://download.sciencepg.com/pdf/10.11648.j.ijec.20180202.14},
      abstract = {The treatment of petroleum produced water before discharge has been made a legal requirement to protect water resources and avoid acute and chronic toxicities. Activated carbon (AC) has been widely used worldwide as an effective medium for the adsorption of biological and chemical contaminants in advance waste water, but its use is limited by its high cost. This study aimed to apply locally prepared activated carbons from coconut and palm kernel shells waste for the abatement of chemical oxygen demand (COD), turbidity, total alkalinity and conductivity in petroleum produced water. Chemical analyses of the petroleum produced water were done to establish the characteristics of the water before and after contacting with the activated carbons for 60 min. The results revealed the COD was reduced to 9.38% by PKSAC, 15.63% by CNTAC and 45.31% by ZC at the 45th min. The total alkalinity reduction was 27.27% for both PKSAC and CNTAC, and 36.36% for ZC. Also, turbidity of the waste water was reduced to 3.48% for CNTAC, 5.56% for PKSAC at the end of 60 min but an anomaly was observed for ZC, where the percentage turbidity of the water increased from 2.78% to 5.36% from the first 45 to the 60 min. The reduction of conductivities of the solution occurred in the first 15 min. The anomalous behaviours observed by all the carbons are an indication of the consumption of vacant active sites on the surface of the carbons for further uptake. This study has revealed some latent facts about the usefulness and effectiveness of granular activated carbons produced from agricultural waste materials which advances existing knowledge in the use of local agro-waste materials for AC preparation.},
     year = {2018}
    }
    

    Copy | Download

  • TY  - JOUR
    T1  - Application of Locally Produced Activated Carbons for Petroleum Produced Water Treatment
    AU  - John Bentil
    AU  - William Kwame Buah
    Y1  - 2018/12/26
    PY  - 2018
    N1  - https://doi.org/10.11648/j.ijec.20180202.14
    DO  - 10.11648/j.ijec.20180202.14
    T2  - International Journal of Environmental Chemistry
    JF  - International Journal of Environmental Chemistry
    JO  - International Journal of Environmental Chemistry
    SP  - 49
    EP  - 55
    PB  - Science Publishing Group
    SN  - 2640-1460
    UR  - https://doi.org/10.11648/j.ijec.20180202.14
    AB  - The treatment of petroleum produced water before discharge has been made a legal requirement to protect water resources and avoid acute and chronic toxicities. Activated carbon (AC) has been widely used worldwide as an effective medium for the adsorption of biological and chemical contaminants in advance waste water, but its use is limited by its high cost. This study aimed to apply locally prepared activated carbons from coconut and palm kernel shells waste for the abatement of chemical oxygen demand (COD), turbidity, total alkalinity and conductivity in petroleum produced water. Chemical analyses of the petroleum produced water were done to establish the characteristics of the water before and after contacting with the activated carbons for 60 min. The results revealed the COD was reduced to 9.38% by PKSAC, 15.63% by CNTAC and 45.31% by ZC at the 45th min. The total alkalinity reduction was 27.27% for both PKSAC and CNTAC, and 36.36% for ZC. Also, turbidity of the waste water was reduced to 3.48% for CNTAC, 5.56% for PKSAC at the end of 60 min but an anomaly was observed for ZC, where the percentage turbidity of the water increased from 2.78% to 5.36% from the first 45 to the 60 min. The reduction of conductivities of the solution occurred in the first 15 min. The anomalous behaviours observed by all the carbons are an indication of the consumption of vacant active sites on the surface of the carbons for further uptake. This study has revealed some latent facts about the usefulness and effectiveness of granular activated carbons produced from agricultural waste materials which advances existing knowledge in the use of local agro-waste materials for AC preparation.
    VL  - 2
    IS  - 2
    ER  - 

    Copy | Download

Author Information
  • Department of Civil Engineering, Takoradi Technical University, Takoradi, Ghana

  • Department of Mineral Engineering, University of Mines and Technology, Tarkwa, Ghana

  • Section